Product ID:F-117/117B ACID COMPONENT, F-39P01 PART 2
MSDS Date:04/25/1996
FSC:8010
NIIN:LLH762268
Kit Part:Y
MSDS Number: CGSYM

SHERWIN WILLIAMS

3560 ELM AVE
PORTSMOUTH, VA 23704
US

Emergency Phone: 804-397-2223

Info Phone: 804-397-2223

Cage: 54626

SHERWIN-WILLIAMS, SEAGUARD

PORTSMOUTH, VA 23704 US

Telephone: 757-397-2223

Cage: 60163

PHOSPHORIC ACID; (PHOSPHORIC ACID 75%) (SARA 313) (CERCLA).

CAS: 7664-38-2

RTECS: TB6300000

Fraction By Weight: <20%

OSHA PEL 1 MG/M3

ACGIH TLV: 1 MG/M3; 3 STEL

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

ISOPROPYL ALCOHOL; (IPA 99% (2-PROPANOL)) (SARA 313). VP

CAS: 67-63-0

RTECS: NT8050000

Fraction By Weight: <70%

OSHA PEL 400 PPM

ACGIH TLV: 400 PPM; 500 STEL

7.36 LBS/GAL; 882 G/L.

RTECS: 9999999VO

OSHA PEL N/K

ACGIH TLV: N/K

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:BREATHING OF HIGH VAPOR CONCENTRATIONS
MAY PRODUCE NARCOSIS. LIQUID MAY CAUSE MINOR SKIN IRRITATION AND
DEFINITE EYE IRRITATION. CORROSIVE; HARMFUL IF INHALED CAUSES NOSE
AND THROAT IRRITATION. CAUSES EYE IRRITATION. CAUSES SKIN
IRRITATION. REPEATED AND PROLONGED OVEREXPOSURE TO SOLVENTS COULD
CAUSE (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: PERMANENT BRAIN AND NERVOUS SYSTEM
DAMAGE. INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING AND
INHALING CONTENTS MAY BE HARMFUL OR FATAL.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:INHAL: REMOVE TO FRESH AIR. RESTORE BREATHING. CONSULT MD.
SKIN: IMMEDIATELY FLUSH SKIN W/PLENTY OF WATER FOR AT LEAST 15
MINUTES WHILE REMOVING CONTAMINATED CLOTHING/SHOES. GET IMMEDIATE
MEDICAL ATTE NTION. WASH CLOTHING BEFORE REUSE. DESTROY SHOES.
EYES: FLUSH IMMEDIATELY W/LARGE AMOUNTS OF WATER FOR AT LEAST 15
MINUTES. GET IMMEDIATE MEDICAL ATTENTION. INGEST: GET MEDICAL
ATTENTION IMMEDIATELY.

Flash Point Method:SCC
Flash Point:63.0F,17.2C
Lower Limits:2.0%
Upper Limits:12.0%
Extinguishing Media:WATER FOG, ALCOHOL, DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . WATER MAY BE USED TO COOL CONTAINERS. IF WATER IS USED
FOG NOZZLES ARE PREFERRED.
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED. VAPORS
MAY MIGRATE TO IGNITION SOURCE & CAUSE FLASH FIRE. ISOLATE FROM
HEAT, SPARKS, ELECTRICAL EQUIPMENT, APPLIANCES, (SUPDAT)

Spill Release Procedures:IN CASE OF SPILLAGE ABSORB WITH INERT MATERIAL
AND DISPOSE OF IN ACCORDANCE WITH APPLICABLE REGULATIONS OF EPA AND
OTHER LOCAL, STATE AND FEDERAL AUTHORITIES.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:STORE AWAY FROM HEAT, SPARKS & OPEN
FLAME. AVOID PRLNGD SKIN CONTACT. DO NOT BREATHE SPRAY MIST. STORE
IN A COOL, DRY AREA W/VENT SUITABLE (SUPDAT)
Other Precautions:GROUND CONTAINERS WHILE POURING. AVOID SPONTANEOUS
COMBUSTION OF CONTAMINATED RAGS OR OTHER ORGANIC MATERIALS. EMPTY
CONTAINERS MAY RETAIN HAZARDOUS PROPERTIES AND CAN BE DANGEROUS.

Respiratory Protection:NIOSH APPRVD RESP TYPES SUITABLE FOR MATLS
LISTED. NIOSH APPRVD CHEMICAL/MECHANICAL FILTERS RECOM WHEN VENT IS
RESTRICTED. DO NOT BREATHE (DUST, VAPS OR SPRAY MIST). WEAR APPROP,
NIOSH APPRVD RESP DUR ING & AFTER APPLICATION UNLESS (SUPDAT)
Ventilation:SUFFICIENT VENT IN VOL & PATTERN TO KEEP AIR CONTAM BELOW
CURRENT APPLIC OSHA PEL OR ACGIH'S TLV LIMIT. USE W/ADEQ VENT.
Protective Gloves:CHEMICAL RESISTANT PLASTIC OR RUBBER.
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGS (SUPDAT)
Other Protective Equipment:ANSI APPRVD EYE WASH & DELUGE SHOWER . AS
REQD TO AVOID WETTING CLTHG. USE PROT CREAMS WHERE SKIN CNTCT IS
LIKELY.
Work Hygienic Practices:REMOVE & WASH CONTAMINATED CLOTHING BEFORE
REUSE. AVOID CONTACT W/EYES, SKIN & CLOTHING. WASH THOROUGHLY AFTER
HANDLING.
Supplemental Safety and Health
EXPLO HAZ: PILOT LIGHTS, FLAMES & OTHER SOURCES OF IGNITION. FLAMMABLE
LIQUID & VAPOR. HNDLG/STOR PRECS: FOR STORING MATERIALS LISTED IN
INGREDIENT SECTION. RESP PROT: AIR MONITORING RECORDS VAPOR/MIS T
LEVELS BELOW APPLICABLE LIMITS. FOLLOW RESP MFR DIRECTIONS FOR USE.
EYE PROT: & FULL LENGTH FACESHIELD .

Boiling Pt:B.P. Text:>180F,>82C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Spec Gravity:0.90
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:INSOLUBLE
Appearance and Odor:LIQUID; ALCOHOL ODOR.
Percent Volatiles by Volume:100

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, METALS SUCH AS ALUMINUM, ZINC, TIN, ETC. AVOID
CYANIDES, SULFIDES, SULFITES & STRONG BASES.
Stability Condition to Avoid:EXCESSIVE HEAT, SPARKS OR OPEN FLAME.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.

Waste Disposal Methods:PLACE IN CLOSED CONTAINERS. DISPOSE OF PRODUCT
IN ACCORDANCE WITH LOCAL, COUNTY, STATE AND FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.